Toyota Toyoace 14B-T Cab Chassis (1984-1995) (1984–1995)

The TOYOTA TOYOACE Base, a no-nonsense workhorse, earned its stripes across New Zealand during the 80s and 90s. Its robust design made it a staple on farms and construction sites. If you own one of these dependable trucks, this wiki provides essential information for its upkeep and longevity.

Parts for the Toyota Toyoace 14B-T Cab Chassis (1984-1995)

• Wheel Cylinder (20)
• Radiator Cap (13)
• Air Filter (11)
• Wheel Cylinder Rear (9)
• Oil Filter (8)
• Wheel Bearing Kit/Hub Front (7)
• Cylinder Head Gasket (6)
• Shocks / Strut Rear (5)
• Universal Joint / Coupling Front (5)
• Universal Joint / Coupling Rear (5)
• Master Cylinder Clutch (4)
• Fuel Filter (4)
• Drive Belt Alternator (3)
• Clutch Slave Cylinder (3)
• Oil Pressure Switch/Sender (3)
• Alternator (3)
• Suspension Bush Front Shock Absorber - Upper (2)
• Clutch Slave Cylinder Kit (2)
• Brake Shoe Rear (2)
• Oil Seal Hub (2)
• Brake Caliper Kit Front (2)
• Bearing Clutch Spigot (2)
• Temperature Sensor / Sender Coolant (2)
• Bearing Clutch Release (2)
• Starter Motor (2)
• Wiper Blade Front (2)
• Brake Shoe Front (2)
• Tie Rod End (2)
• Seal Ring (2)
• Filter Service Kit (2)
• Engine Oil (2)
• Master Cylinder Kit Clutch (2)
• Brake Pads Front (2)
• Oil Seal Hub Rear Inner (2)
• Tie Rod (2)
• Oil Seal Axle / Drive Shaft - Rear Inner (1)
• Clutch Drive Plate Engine (1)
• Oil Seal Hub Rear Outer (1)
• Oil Seal Axle/Drive Shaft (1)
• Thermostat (1)
• Drive Belt Air Conditioner (1)
• Oil Cap (1)
• Gear Oil Gearbox (1)
• Wheel Bearing Grease Rear (1)
• Cylinder Head (1)
• Shocks / Strut Front (1)
• Wheel Bearing Kit/Hub Rear (1)
• Wheel Bearing Grease Front (1)
• Sway Bar Coupling Mount (1)
• Suspension Bush Shock Absorber (1)
• Suspension Bush Rear Leaf Spring - Shackle (1)
• Suspension Bush Rear Shock Absorber - Lower (1)
• Suspension Bush Rear Shock Absorber - Upper (1)
• Suspension Bush Rear Leaf Spring - Front Eye (1)
• Suspension Bush Rear Leaf Spring - Rear Eye (1)
• Suspension Bush Front Shock Absorber - Lower (1)
• King Pin Kit (1)
• Suspension Bush Front Leaf Spring - Shackle (1)
• Suspension Bush Front Leaf Spring - Front Eye (1)
• Steering Bearing Power Steering Pump (1)

Known issues

Owners of TOYOACE Base trucks often encounter these issues:
• Rust: The cab floor and roof are particularly susceptible to rust. Regular inspections and preventative measures can help mitigate this.
• Overheating: Especially when carrying heavy loads, overheating can be a concern. Maintaining the cooling system is critical.
• Gearbox Weakness: The synchromesh in the gearbox, especially for 2nd gear, can wear out over time. Be mindful of shifting smoothness and address any issues promptly.

WOF tips

When preparing your TOYOACE Base for its WOF (Warrant of Fitness) inspection, pay attention to the following potential fail points:
• Excessive play in steering idler arm: Ensure the steering system is in good condition.
• Corrosion around windscreen and cab mounts: Address any rust or corrosion issues thoroughly.

About the Toyota Toyoace 14B-T Cab Chassis (1984-1995)

The TOYOACE Base: A Kiwi Workhorse

While not steeped in motorsport glory or boasting groundbreaking engineering firsts, the TOYOACE Base holds a special place in the hearts of many New Zealanders. These trucks were a familiar sight, diligently performing demanding tasks day in and day out. Their simple, rugged construction meant they could handle tough conditions, making them an indispensable asset for numerous businesses and rural properties.

Maintaining Your TOYOACE Base

Keeping your TOYOACE Base in good working order requires regular maintenance and attention to potential problem areas. The following sections provide guidance to help you extend its lifespan and reliability.

Questions owners ask

What are some common problems I might encounter with my 1984-1995 TOYOACE in New Zealand?

TOYOACE Base owners in NZ often deal with rust, particularly in the cab floor and roof. Overheating, especially when carrying heavy loads, is another common issue. Also, the gearbox synchromesh, especially for 2nd gear, can wear out. Regular servicing every 5000km can help prevent these issues.

Where can I get parts for my 1984-1995 TOYOTA TOYOACE in NZ?

CARFIX stocks 135 SKUs for the TOYOTA TOYOACE 1984-1995. You can find a wide range of parts, from filters and brake components to suspension parts, to keep your TOYOACE running smoothly.

What should I check on my TOYOACE before its WOF inspection?

When prepping your 1984-1995 TOYOACE for its WOF, pay close attention to potential fail points like excessive play in the steering idler arm and any corrosion around the windscreen and cab mounts. These are common issues that can cause a WOF failure.

My TOYOACE is overheating, what could be the cause?

Overheating in a TOYOACE, especially when loaded, often points to cooling system issues. Check the thermostat, water pump, and radiator for proper function. Ensuring the cooling system is in good condition is critical for these workhorses, especially with the 5000km service interval.

Is rust a major problem for the TOYOACE Base in New Zealand?

Yes, rust is a significant concern for TOYOACE Base trucks in New Zealand due to the climate and the age of these vehicles. The cab floor and roof are particularly vulnerable. Regular rustproofing and inspections are recommended to prevent serious damage.

What kind of maintenance schedule should I follow for my TOYOACE?

A 5000km service interval is recommended for the TOYOACE 1984-1995. This includes oil and filter changes, checking fluid levels, inspecting brakes, and other essential maintenance tasks to keep your truck in good working order.

Are there any common gearbox problems with the TOYOACE?

Yes, a common issue with the TOYOACE gearbox is wear on the synchromesh, particularly for 2nd gear. If you notice difficulty shifting or grinding noises, it's important to address the issue promptly to prevent further damage.