Toyota Allion 1NZ-FE Sedan 80kW (2001-2005) (2001–2005)

The Toyota Allion and Corona Premio are known for their reliability and practicality, making them popular choices for Kiwi drivers. This guide provides essential information to help you maintain your vehicle and address potential issues.

Parts for the Toyota Allion 1NZ-FE Sedan 80kW (2001-2005)

• Engine Oil (17)
• Power Steering Fluid (14)
• Automatic Transmission Fluid (12)
• Radiator Coolant (10)
• Brake Pads Front (8)
• Tie Rod End (7)
• Thermostat (6)
• Water Pump (6)
• Cabin Filter (6)
• Oil Filter (6)
• Spark Plug (4)
• Air Filter (4)
• Disc Brake Rotor Front (4)
• Wiper Refill (4)
• Steering Rack End (3)
• Wheel Bearing Kit/Hub Rear (3)
• Engine Oil Pan Gasket (3)
• Starter Motor (3)
• Oil Seal Crank Shaft Front / Timing Front (3)
• Brake Fluid (3)
• Wheel Nut (3)
• Brake Shoe Rear (3)
• Wheel Bearing Kit/Hub Front (3)
• Steering Rack Boot Kit (3)
• Sway Bar Link (3)
• Brake Hose Front (2)
• Shocks / Strut Front (2)
• Drive Belt Power Steering (2)
• Wheel Cylinder Rear (2)
• Valve Cover Gasket (2)
• Timing Kit (2)
• Engine Mount Front (2)
• Cylinder Head Gasket (2)
• Head Set/Valve Regrind Gasket Set (2)
• Engine Mount Rubber Buffer (2)
• Timing Chain Guide (2)
• Alternator (2)
• Ignition Coil (2)
• Fuel Filter (2)
• Automatic Transmission Filter (2)
• Sump/Drain Plug (2)
• Wiper Blade Front (2)
• Ball Joint Front (1)
• Engine Mount (1)
• Valve Cover Bolt Seal/Washer (1)
• Timing Chain (1)
• Dipstick (1)
• Ball Joint Front Lower (1)
• Throttle Body Gasket (1)
• Induction Hose (1)
• Cv Joint (1)
• Timing Tensioner (1)
• Cv Joint Boot Kit Front Left Inner (1)
• Cv Joint Boot Kit Front Right Inner (1)
• Engine Mount Rear (1)
• Brake Shoe Fitting Kit Rear (1)
• Brake Caliper Piston Front (1)
• Thermostat Housing (1)
• Brake Caliper Kit Front (1)
• Sway Bar Link Front (1)

Known issues

Owners should be aware of potential issues such as premature wear of front suspension components (ball joints and bushings), the timing belt needing replacement around 100,000km, and corrosion in the exhaust system. Front suspension wear can often be detected from around 120,000km.

WOF tips

During Warrant of Fitness inspections, pay attention to excessive play in steering components, rust around the rear suspension mounts, and any oil leaks from the engine and transmission.

About the Toyota Allion 1NZ-FE Sedan 80kW (2001-2005)

Maintaining your Allion/Corona Premio involves regular servicing and attention to specific areas. The recommended service interval is 15,000km. Keep an eye on common wear points to ensure your vehicle remains in top condition. When undertaking repairs, you may require parts like a thermostat housing, wheel nuts, CV joint, radiator coolant, head set/valve regrind gasket set, oil filter, timing chain, front brake hose, automatic transmission filter, dipstick, induction hose, front shocks/struts, pre-catalytic converter oxygen sensor, front strut boot kit, and conversion gasket set.

Questions owners ask

What are the common WOF issues for a TOYOTA ALLION;CORONA PREMIO 2001–2005 in New Zealand?

For your TOYOTA ALLION;CORONA PREMIO 2001–2005, WOF inspections often highlight excessive play in steering components, rust around the rear suspension mounts, and any oil leaks from the engine and transmission. It's a good idea to check these areas before your inspection.

How often should I service my TOYOTA ALLION;CORONA PREMIO 2001–2005?

The recommended service interval for your TOYOTA ALLION;CORONA PREMIO 2001–2005 is every 15,000km. Regular servicing helps maintain its condition and address common wear points.

What are the typical suspension problems I might encounter with my TOYOTA ALLION;CORONA PREMIO 2001–2005?

Owners of the TOYOTA ALLION;CORONA PREMIO 2001–2005 should be aware of premature wear in front suspension components, particularly ball joints and bushings. These issues can often become noticeable from around 120,000km. You might need parts like front shocks/struts or a front strut boot kit.

When should the timing belt be replaced on a TOYOTA ALLION;CORONA PREMIO 2001–2005?

The timing belt on your TOYOTA ALLION;CORONA PREMIO 2001–2005 typically needs replacement around 100,000km to prevent potential engine damage.

Where can I get an oil filter or timing chain for my TOYOTA ALLION;CORONA PREMIO 2001–2005 in NZ?

CARFIX stocks 228 SKUs for your TOYOTA ALLION;CORONA PREMIO 2001–2005, including essential parts like oil filters and timing chains. You can find these and other components like thermostat housings, CV joints, and front brake hoses on our website.

What are some common parts that wear out on a TOYOTA ALLION;CORONA PREMIO 2001–2005?

Common wear points on your TOYOTA ALLION;CORONA PREMIO 2001–2005 include front suspension components (ball joints and bushings), the timing belt, and the exhaust system which can be prone to corrosion. Other parts you might need to replace over time include radiator coolant, head set/valve regrind gasket sets, and automatic transmission filters.